Emergency Procedures

•FA CALL BUTTON 3x.

•F100-Produces 3 Chimes.

•UQ/F70-Produces 3 single HI/Low Chimes.

•Cycle Fasten Seatbelt selector 3X.

•Produces 6 Single HI Chimes.

#Brace signal @ 300ft/30 sec.

1, IDENTIFY - DG.

2, ADVISE FA - Handling Method.

3, PA - Alert Pax/Illuminate Ignition source.

4, FLTDK DOOR - Closed/Locked, protect against Vapour/ignition/Flash Fire.

5, MAX AIRFLOW - FLTDK/Cabin(Depress Cabin while on DES until Cabin Diff = O.

6, CABIN TEMP - Lower, reduce Vapour & ignition potential.

7, QRH - Smoke/Toxic Fumes Removal Procedure.

8, CONTACT - Company Network Operations.

# Require Captains approval to isolate DG.

•INITIAL CONTACT;

1, DG ITEM & UN No.

2, LOCATION.

3, EXTENT OF SPILLAGE.

4, If SMOKE/FUMES/FIRE.

5, COLOUR/DENSITY/SMELL of smoke /fumes.

•Follow up Contact;

1, STATUS of situation.

2, EFFECT on Pax/FA.

1, Slide seat fully back.

2, Move legs away from rudder pedals.

3, Maintain clear airway.

4, Cross arms across chest & place under shoulder Harness.

5, Lock/tighten seat harness.

6, Administer 100% Oxygen.

7, PA (FA) Alliance Pilots, Doctor, Nurse, Paramedic on board.

H - Item HIDDEN.

O - Item OBVIOUSLY suspicious

T - Item TYPICALLY found here

U - UNAUTHORISED access/activity

P - PUBLIC access area.

1, Asylum Seekers.

2, Irrational Individuals.

3, Publicity Seekers.

4, Organised State or Non State Terrorist Groups.

1, FOLLOW Hijackers instruction

2, CONTACT FLTDK

3, ATTEMPT keep Hijackers out of FLTDK

4, ESTABLISH Hijackers have weapons.

1, Stay Calm.

2, Use established Crew Chain of Command.

3, Retain Passive Control.

4, Slow everything down.

5, Be cautious about what u hear from others.

6, Don't assume Hijackers are working alone.

7, Be responsive in a Regulated Tone & Use direct questions.

8, Avoid Political/Moral/Ethical Discussions.

9, Do not argue or disagree.

10, Relieve His/Her Anxiety & maintain effective Communication.

11, Discourage use of mobile phone.

12, Beware of Stockholm Syndrome.

13, Ration Food/Beverages.

14, Do not serve Alcohol.

15, Maintain Hygiene.

16, Pilots must try to land.

17, Stall for time after landing.

18, Calm and reassure Pax.

19, Ensure Pax do not form;

-Groups

-Isolate themselves

-Intervene/Hero

20, Calm Hijacked.

21, Keep Hijacker informed.

22, Observe the Characteristics & Behaviour Hijacker.

23, Allow Hijacker to make own decisions.

24, Feed Hijackers.

FL220- 10mins

FL250- 3-5mins

FL280- 2.5-3mins

FL300- 1-2mins

FL350- 30-60sec

MILD;

F - Fatigue

L - Listlessness & Vague Distress

L - Lack of Concentration

MODERATE;

L - Lack of self Criticism

M - Mood change &a Confusion

B - Breathlessness

SEVERE;

B - Blue Tinge to Lips & Fingers

L - Loss of Consciousness

D - Death

#Treatment;

1, Give Oxygen @ 4L p/m (HIFLO).

2, Loosen tight clothing around neck.

Recognition;

1, Joint pain.

2, Tingling, numbness & general discomfort of the skin.

3, Weakness.

4, Chest tightness.

5, Visual impairment.

6, Dizziness.

7, Altered conscious state or unconsciousness.

Treatment;

1, Place person in Horizontal position.

2, Give Oxygen @ 4L p/m (HI FLO).

3, Observe person.

4, Keep person warm.

5, Advise person to keep still.

INITIAL CONTACT;

1, Location.

2, Source.

3, Colour/Density/Smell of smoke.

FOLLOW UP CONTACT;

1, STATUS.

2, EFEECT.

3, No EXTINGUISHERS used.

OVEN DRILL;

1, FA Turn off oven/ Pilot Galley PWR off.

2, Open door slightly.

3, insert nozzle & Discharge short burst.

4, Close Door.

5, Wait 1 min.

6, Open Door.

7, Establish if fire has extinguished.

8, Repeat procedure until fire has extinguished.

Waste Bin Fire;

1, Open flap slightly.

2, Insert Nozzle & Discharge short burst.

3, Close flap.

4, Wait 1 Min.

5, Open flap.

6, Establish if fire is extinguished.

7, Repeat procedure until fire has extinguished.

8, Saturate contents.

9, Remove contents.

Lithium Battery Fire;

1, Discharge Fire Extinguisher.

2, saturate with Cold water or non alcoholic liquid.

3, immerse in cold water where possible.

CAPTAIN;

- Torch

- Hand held Beacon

- Monitor/Assist with Cabin Evac

- Once Evac complete, move upwind & assist FO with gathering Pax and head count.

# Assist Evacuation with Incapacitated FA/CM.

FO;

- Torch

- Pax Manifest

- Evac first Ava exit

- Utilise ABP to keep base of exit clear

- Direct Pax upwind & complete head count

#Priorities;

P-Protection.

L-Location.

W-Water.

F-Food.

#Protection Elements;

1, First Aid.

2, Clothing.

3, Shelter.

4, Fire.

#Location Elements;

1, Terrain.

2, Vegetation Cover.

3, Sea Conditions.

4, Signalling Devices:

-RB

-A/C Fuselage

-SOS(Use Rocks)

Immediate DESERT Actions;

1, Activate Beacon.

2, Rest in Shade.

Immediate WATER Action;

1, HELP ( Heat Escape Lessening Posture).

2, Group Huddle.

Immediate RAFT Actions;

R-Release LR from A/C.

E-Establish Command.

D-Deploy RB.

C-Collect Survivors.

S-Stabilise &a Secure Rafts.

E-Erect LR Canopy.

Precautions;

1, Avoid getting too close to liquid flammable fires. (Reduces risk of Scattering/Splashing & spreading the fire.).

2, Avoid inhalation (PBE)

3, High concentrations of agent can result in;

-Dizziness

-Impaired Concentration

-Impaired Co-Ordination

4, Before Discharge on FLTDK;

-Oxygen Mask on

-Smoke goggles on

-Regulators set 100%(Diluter LVL)

5, Electrical fires, do not allow any part of the extg to make contact with live wires.

PRE FLIGHT SERVICEABILITY;

-Quell/Chubb;

•Red Disc reads FULL.

H3R;

•Pressure gauge in the green.

•Ensure Lock Pin in place

•Tamper Evident Seal in tact.

OPERATION; PASS!!!

Quell/Chubb;

1, Hold upright by operating handle.

2, Push up Red Catch.

3, Squeeze operating handle hard with palm of hand.

4, After use, return the extg to original stowage and secure.

H3R;

1, Hold upright & pull ring lock pin breaking plastic tamper evident seal.

2, Squeeze operating Handles together to Discharge.

3, After use, return to original stowage and secure.

DURATION;

Quell/Chubb - 10sec/2m

H3R - 10sec/4m

PRE FLIGHT SERVICEABILITY;

Scott;

1, Moisture Strip in inspection window is BLUE, (faded to white/grey).

2, Unserviceable - PINK.

ESSEX;

1, Tamper Evidence Seal in tact.

2, Humidity Indicator - BLUE.

DURATION;

Both - 15 mins.

OPERATION;

SCOTT;

1, Remove unit from case.

2, Tear Red Pull Strip & Remove from bag.

3, Pull out Actuator Ring ( Don't use unless Gas Flow).

4, Bend fed, grasp hole in neck seal with Thumbs, insert Chin into hole & Pull hood across face and over head.

5, Pull hood down until headband firmly engages forehead.

6, Ensure clothing/Jewellery/hair is clear of neck seal.

7, When gas flow noise stops, immediately move to non hazardous area & Remove hood.

REMOVAL;

1, Move to safe area clear of Fire & toxic fumes.

2, Insert both hands under neck seal.

3, Ease hood up over the head & clear the face.

4, Brush Hair.

5, Stow in a safe, dry place away from heat, fire, water, allow time to cool. Use Valet cupboard or overhead locker.

ESSEX;

1, Grasp red strap attached to lid & Pull sharply to break Taper Evidence Seal.

2, Grasp yellow nylon strap & pull the PBE from bracket to remove unit.

3, Open foil seal pouch, tear in the direction of arrows using the red tear Strip.

4, Position front of hood correctly. (Should only seal foil area).

5, Unfold Hood to reveal O2 cylinders.

6, Grasp both cylinders with left hand, Grasp Ball/Chord with right hand.

7, Pull Ball/Chord sharply, O2 flow within 2 mins, actuated green light.

8, Place both hands in neck seal, palms facing each other, stretch neck seal open.

9, Guide hood over back of head & down over the face.

10, Ensure clothing/jewellery/hair is clear of neck seal.

11, Adjust glasses through hood.

REMOVAL;

1, Move to safe area.

2, Insert both hands under neck seal.

3, ease hood over the head & clear of face.

4, Brush hair.

5, Store in dry, safe place away from Heat/Fire/Water.

Pre Flight Serviceability check;

1, Minimum Pressure 1500psi.

2, Dust Covers are in place.

PRECAUTIONS;

1, Do not allow O2 to flow into oil/grease.

2, Do not use O2 near naked flame.

3, Wipe heavy make up or grease from face.

4, 50psi should remain in used Portable O2 bottle.

5, Avoid bumping/dropping cylinder.

6, No ignition source within 4m.

7, HI Flo used for adults/FA performing duties after Depress.

8, Lo Flo used for children under 5 years.

DURATION;

*200L

-HI Flo- 50 mins

-LO Flo- 100mins

-Combined- 33mins

OPERATION;

R - Remove Dust Cover.

I - Insert connector to Req Flow outlet.

T - Turn On/Off Regulator valve fully anti-clockwise.

E - Ensure O2 flowing by checking Flow Indicator has expanded on the rebreather bag.

TROUBLE SHOOTING;

No Flow;

1, Check connections.

2, Check bottle contents.

# Used masks, place in sickness bag, place at fwd galley for collection by engineer, notify captain so entry can be made in flight log.

FLEXI CUFFS;

Pre-Flight serviceability;

- Correct number Location.

• 2 Cuffs/ 1 Cutter/ 6 witness forms.

• Behind Captain seat.

Precautions;

1, Do not attach Pax to A/C structure.

2, Ensure/Maintain surveillance intermittently that the device is not causing injury.

3, To replace restraint, fit new one first.

4, Do not apply any coverings to face/head.

5, Restraint can only be removed once A/C is on the ground and security personnel have arrived on board.

6, CM will detail one of the restraint team to sit next to Pax on LDG to perform Buddy system in case of EVACUATION.

PLB (Portable Locator Beacon)

Pre flight serviceability;

- Correct number/Location.

Duration;

- 24hrs @ -20c, longer in warmer ambient temps.

- Range - International.

MEGAPHONE;

#Use for crowd control, PA U/S.

Pre flight serviceability;

1, Squeeze handle momentarily.

2, Ensure Audible Click is present.

Precaution;

1, Do not place outlet close to person due to load output volume.

Cabin Torch;

Pre flight serviceability;

- Red Blinker light is flashing every 3 -10sec.

FLTDK Torch;

Pre flight serviceability;

- Correct number and Location.

DURATION;

Approx 4 hrs.

DG Kit;

1, Goggles

2, 2 x Gloves

3, 2 x Plastic Bags

4, Plastic bag ties

5, Absorbent Mats

6, Labels.

PSU O2;

- Once mask pulled, continuous flow.

- Duration 14 mins.

46 man;

- 44kg

- 15 sec inflation time

- Max capacity 69(50% overload)

10 man;

- 27kg.

- max capacity 15.

Precaution;

- LR must be in water & clear of the leading edge prior to inflation.

Pre flight serviceability;

46 man;

-Correct number/Location.

-Upper- inflation line facing aisle.

-Lower- inflation line facing fuselage.

10 man;

- Correct number/Location.

LAUNCH;

1, Remove from stowage.

2, Check for Fire/Smoke/High Water/Obstruction.

3,Open useable Exit.

4, Unlatch 3 buckles that hold the LF in position.

5, Remove seat covers & Cusions.

6, Remove LF with ABP.

7, 46er, upper LF LH 1st Emer Window, lower LR RH 1st Emer window.

8, 10er, Place directly underneath into emergency window rows.

9, Fasten seat belt nearest exit, pass inflation line through belt, clip it onto it self.

10, Alternatively inflation line can be attached to leg of Pax seat.

46 man;

- 44kg

- 15 sec inflation time

- Max capacity 69(50% overload)

10 man;

- 27kg.

- max capacity 15.

Precaution;

- LR must be in water & clear of the leading edge prior to inflation.

Pre flight serviceability;

46 man;

-Correct number/Location.

-Upper- inflation line facing aisle.

-Lower- inflation line facing fuselage.

10 man;

- Correct number/Location.

LAUNCH;

1, Remove from stowage.

2, Check for Fire/Smoke/High Water/Obstruction.

3,Open useable Exit.

4, Unlatch 3 buckles that hold the LF in position.

5, Remove seat covers & Cusions.

6, Remove LF with ABP.

7, 46er, upper LF LH 1st Emer Window, lower LR RH 1st Emer window.

8, 10er, Place directly underneath into emergency window rows.

9, Fasten seat belt nearest exit, pass inflation line through belt, clip it onto it self.

10, Alternatively inflation line can be attached to leg of Pax seat.

1, Life Line.

2, Survival Kit.

3, Bailing Bucket.

4, Water Activated Locator Lights.

5, Heaving Line.

6, Sea Anchor.

7, Life Raft Knife.

8, Hand Pump.

1, Life Line.

2, Survival Kit.

3, Bailing Bucket.

4, Water Activated Locator Lights.

5, Heaving Line.

6, Sea Anchor.

7, Life Raft Knife.

8, Hand Pump.

1, HD/HN Flare.

2, Signalling Mirror.

3, Sea Dye Marker.

4, Survival Manual.

5, Whistle.

6, Miniature Torch/Flashlight.

7, Repair Kit.

8, First Aid Kit.

9, 5 Water Packs.

10, Dehydrated Sponge.

11, Utility Knife.

12, Canopy.

1, Life Line.

2, Survival Kit.

3, Bailing Bucket.

4, Water Activated Locator Lights.

5, Heaving Line.

6, Sea Anchor.

7, Life Raft Knife.

8, Hand Pump.

1, HD/HN Flare.

2, Signalling Mirror.

3, Sea Dye Marker.

4, Survival Manual.

5, Whistle.

6, Miniature Torch/Flashlight.

7, Repair Kit.

8, First Aid Kit.

9, 5 Water Packs.

10, Dehydrated Sponge.

11, Utility Knife.

12, Canopy.

1, Distribute Rods.

2, Insert Support Rod into respective eyelet in each corner.

3, Erect centre mask.

4, Spread Canopy out over the raft Ensure "Zipper Vent Flap" placard is positioned above the boarding station.

# Following steps should be performed on upwind side first.

5, Grasp Canopy &a bring it over the tips of support rod.

6, Place rod through the holes into top of Canopy & press to secure.

7, Tie down life raft Canopy slides.

8, Repeat last 4 steps on downwind side.

1, Life Line.

2, Survival Kit.

3, Bailing Bucket.

4, Water Activated Locator Lights.

5, Heaving Line.

6, Sea Anchor.

7, Life Raft Knife.

8, Hand Pump.

1, HD/HN Flare.

2, Signalling Mirror.

3, Sea Dye Marker.

4, Survival Manual.

5, Whistle.

6, Miniature Torch/Flashlight.

7, Repair Kit.

8, First Aid Kit.

9, 5 Water Packs.

10, Dehydrated Sponge.

11, Utility Knife.

12, Canopy.

1, Distribute Rods.

2, Insert Support Rod into respective eyelet in each corner.

3, Erect centre mask.

4, Spread Canopy out over the raft Ensure "Zipper Vent Flap" placard is positioned above the boarding station.

# Following steps should be performed on upwind side first.

5, Grasp Canopy &a bring it over the tips of support rod.

6, Place rod through the holes into top of Canopy & press to secure.

7, Tie down life raft Canopy slides.

8, Repeat last 4 steps on downwind side.

Night End;

- Produces Red Magnesium Sparks.

Day End;

- Produces Orange Smoke.

OPERATION;

1,Position on downwind side of raft.

2, Hold Flare up over the side @ arms length & clear of the raft.

3, Point Flare downwind & away from face.

4, Ignite by unscrewing the cap from the end.

5, Pull Ball sharply to fire.

1, Life Line.

2, Survival Kit.

3, Bailing Bucket.

4, Water Activated Locator Lights.

5, Heaving Line.

6, Sea Anchor.

7, Life Raft Knife.

8, Hand Pump.

1, HD/HN Flare.

2, Signalling Mirror.

3, Sea Dye Marker.

4, Survival Manual.

5, Whistle.

6, Miniature Torch/Flashlight.

7, Repair Kit.

8, First Aid Kit.

9, 5 Water Packs.

10, Dehydrated Sponge.

11, Utility Knife.

12, Canopy.

1, Distribute Rods.

2, Insert Support Rod into respective eyelet in each corner.

3, Erect centre mask.

4, Spread Canopy out over the raft Ensure "Zipper Vent Flap" placard is positioned above the boarding station.

# Following steps should be performed on upwind side first.

5, Grasp Canopy &a bring it over the tips of support rod.

6, Place rod through the holes into top of Canopy & press to secure.

7, Tie down life raft Canopy slides.

8, Repeat last 4 steps on downwind side.

Night End;

- Produces Red Magnesium Sparks.

Day End;

- Produces Orange Smoke.

OPERATION;

1,Position on downwind side of raft.

2, Hold Flare up over the side @ arms length & clear of the raft.

3, Point Flare downwind & away from face.

4, Ignite by unscrewing the cap from the end.

5, Pull Ball sharply to fire.

6, Hold Flare @ 45 deg angle & Maintain until Flare has discharged completely.

7, Store in dry place if only one End has been used.

8, Retain Flare if other End has not been used.

1, Place Lanyard over head.

2, Reflect sunlight from mirror onto near by surface.

3, Slowly bring mirror up to eye level & look through the sight hole until a bright light spot becomes visible.

4, Hold mirror close to eye slowly turn it until bright light is directed to the target.

5, Continually sweep horizon.

RANGE;

- 32km.

1, Place Lanyard over head.

2, Reflect sunlight from mirror onto near by surface.

3, Slowly bring mirror up to eye level & look through the sight hole until a bright light spot becomes visible.

4, Hold mirror close to eye slowly turn it until bright light is directed to the target.

5, Continually sweep horizon.

RANGE;

- 32km.

- Produces Fluorescent Green Dye.

- Duration of 3hrs.

#Must be attached to bracket on the wing during ditching.

1, Place finger in the slot provided in the panel, slide catch up & pull the panel free.

2, Undo dog clip.

3, Instruct ABP to attach the dog clip onto tie down point on the wing.

4, Instruct Pax to use life line to assist the evacuation.

Precaution;

1, Ensure Rope is attached securely to A/C before use.

Operation;

1, Open compartment door.

2, Pull firmly on Rope.

3, Throw Rope out of FLTDK window.

4, Grasp evacuation handle with hand closest to window.

5, Thrust shoulder closest to window & head out.

6, Place both feet on seat & sit on window rail.

7, Grasp Rope.

8, Place both feet on the window rail & lower yourself to the ground.

Precaution;

1, Ensure Rope is attached securely to A/C before use.

Operation;

1, Open compartment door.

2, Pull firmly on Rope.

3, Throw Rope out of FLTDK window.

4, Grasp evacuation handle with hand closest to window.

5, Thrust shoulder closest to window & head out.

6, Place both feet on seat & sit on window rail.

7, Grasp Rope.

8, Place both feet on the window rail & lower yourself to the ground.

Manual Inflation;

1, Hold onto Evacuation Handle or rigid structure with one hand.

2, Reach & Pull the Manual Inflation Handle with other hand.

Non Inflated/Deflated Slide Procedures;

1, Release Tab/Clip in centre of Slide, allow it to free fall (if not already released).

2, Direct 2 ABP to CLB down the escape slide.

3, Direct first ABP to release the Securing Tabs on the way down.

4, Direct both ABP to stretch out the slide & 45 deg angle, using hand held a provided @ the bottom.

5, Direct another ABP to slide down & position themselves @ the bottom of the slide to assist evacuation of Pax.

# Do not persist with deflated slide unless it's the only means of evacuation.

Detach Slide Procedure;

1, Lift the flap @ the top of Slide.

2, Pul detachment handle.

3, Ensure the attachment line breaks.