Use LEFT and RIGHT arrow keys to navigate between flashcards;
Use UP and DOWN arrow keys to flip the card;
H to show hint;
A reads text to speech;
55 Cards in this Set
- Front
- Back
Scale build up effect efficiency |
Insulate not transfer heat. |
|
Mawp |
Max allow working pressure |
|
Water tube |
Fire outside tube |
|
Purpose if bottom blowdown |
Remove sludge. Remove water |
|
Most important valve |
Saftey |
|
What control operate steam |
Pressyrtrol |
|
Hydrobic control |
Aquastat |
|
What causes soot |
Improper combustion |
|
What can cause incomplete combustion |
Lack of air |
|
How to test diaphragm type expanse tank thats water logged |
Knock on side to see if hollow |
|
Indication of water logged expansion tank |
Relief valve will open. No where for expansion to take place |
|
Blower between furnace and stack |
Induced |
|
Proper combustion stack smoke should look like |
Light haze |
|
Mean if black smoke |
Incomplete combustion. |
|
Heavy white smoke |
Tube leak |
|
Purpose of water column |
To slow down water fluctuation so easier to read gauge glass |
|
Correct time to blow down boiler |
When light load still warming up |
|
Saftey valve leak |
Replace |
|
Some cases blow down line has 2 valves what's the procedure to open |
Closes to boiler work way out then w9rk way back |
|
When do you need two valves on bottom |
Exceed 100psi mawp |
|
Benefits of proper water treatment |
Reduce corrosion. Reduce scale buildup by removing oxygen giving proper ph |
|
Good ph for hot water |
8 to 9 |
|
Ph for steam boiler |
10.5 to 11 |
|
Dissolved gasses in water, most harmful is |
Oxygen |
|
Which valve has unrestricted flow through it |
Gate valve |
|
Gauge glass is full, what mean |
Top valve closed or boiler is full. Open top cock to see what comes out |
|
Water level not moving |
Bottom valve is plugged |
|
How often test saftey valve |
Monthly |
|
Proper way to warm up a gauge glass |
Crack open the top valve. Slowly let steam in |
|
Purpose of expansion tank |
As heat goes up pressure goes up. Volume of water changes so tank handle the changes of water volume |
|
What 2 devices control the flow zoned system |
Zone circulator or zone valve |
|
What happens if circulate oversized |
Frequent burner cycling efficiency goes down. Delta t goes down. |
|
Undersized circulator |
Insufficient heat. Not proper gpm |
|
What does a siphon do and how |
Protects steam from entering gauge glass or pressurol. Traps steam with water in bottom |
|
Wtf does a lwco do? |
Shut off burner when water level gets too low |
|
Remedy for cold hydronic boiler |
Bleed out air |
|
Evaporation test how to? |
Shut off feedwater and let the boiler run |
|
How often does steam boiler need internal inspection |
Annualy |
|
How often does hydronic need internal inspection |
5 year |
|
Which boiler can't be used on high pressure |
Cast iron |
|
What can cause boiler explosion |
Out of water adding water to hot dry boiler. Unburned fuel |
|
Purpose of pre purge |
Clears out combustion chamber |
|
Common chemical used as oxygen scavenger |
Sodium sulfite |
|
Common set point for relief valve low pressure hot water |
30psi |
|
What does thermostat directly control on multi zone system |
Zone valve or zone circulator |
|
What enable the aquastat relay on multi zone system |
Zone valve, end switch, thermostat |
|
Commercial boilers have how many aquastat |
Usually 2 |
|
Commercial boilers have what kind of aquastat |
High limit and operation |
|
Purpose of surface blow down |
Impurities that are on the surface |
|
What is water hammer |
When water droplets bang into steam piping around turns. Steam boiler |
|
What causes water hammer |
Surface tension |
|
Calculate gallons per minute |
Btu/hr ÷ (Delta t×500) |
|
Calculate head pressure |
ML × 1.5×.04= |
|
Calculate btu |
Btu out ÷ 33472 |
|
Minimum like size for steam pipe |
1/4 inch |